cairui2003

板框压滤机在三元复合驱采出液废渣处理中的应用
2022/05/09 357
引言随着油田进入高含水后期开发阶段，剩余可采储量逐渐减少，产油量递减严重，采用聚合物驱油、三元复合驱油等三次采油新方法是提高可采储量的重要措施。三元复合驱即碱一表面活性剂一聚合物复合驱，三元复合驱...
View full text
板框压滤机在半脱硫回收中的应用
2022/05/09 514
引言硫回收作为脱硫过程的三个系统之一，其运行情况的好坏直接影响着脱硫系统的运行质量。硫回收的方法有许多,如间歇熔硫法、连续熔硫法、机械处理法等。由于单纯的间歇熔硫法弊端较多，近年来已逐渐被淘汰，目...
View full text
板框压滤机运行中常见故障与应对措施
2022/05/09 511
板框压滤机的工作机理在实际工作中，板框压滤机在运行中的机理相对较为简单，首先要对液压施加力量从而压紧板框组，再将大量沉淀的淤泥从中间进行输送，根据现场的实际情况对其进行分布。因板框压的太紧，淤泥将...
View full text
板框压滤机疑难故障研究与解决方案
2022/05/09 413
引言板框压滤机是污水处理厂对污泥进行压榨处理，固液分离的常用设备，分离效果好，脱水率能够达到80以上，单次处理量比较大，是污泥脱水的理想设备。笔者曾负责新疆伊宁东西区污水处理厂、奇台喇嘛湖梁化工园污...
View full text
板框压滤机在气化煤灰脱水上的应用研究
2022/05/09 479
引言水煤浆气化炉是目前煤化工主流的气化方式,代表性的炉型有GE炉、清华炉、多原料浆炉、四喷嘴气化炉等,它们以低灰分的水煤浆为原料,在气化剂的夹带作用下通过喷嘴高速喷入气化炉内进行短时燃烧,该类型气化炉采...
View full text
板框压滤机在冷轧废水处理中的应用
2022/05/08 366
前言马钢第四钢轧总厂冷轧区域的酸轧、连退和镀锌线在生产过程中会产生大量含酸、碱、油、铬的工业废水，这些废水经过废水处理系统进行处理后，达到国家相关标准后才允许排放，而废水中的污染物则通过化学作用、...
View full text
Application of Plate and Frame Filter Press in Alkaline Desulphurisation
2022/05/08 350
引言近几年碱法脱硫工艺在煤炭提治利用项目中应用广泛，目前碱法脱硫工艺中硫泡沫的处理采用熔硫釜连续熔硫生产熔融硫的工艺。硫泡沫从再生槽溢流至泡沫槽，泡沫槽设有搅拌，使泡沫与清液形成均匀的悬浮液，用泡...
View full text
板框压滤机污泥脱水车间的结构形式与运营
2022/05/08 432
概述新的环保法实施，对市政污水和污泥的处理有了更严格的要求，促使目前大多数污水处理厂对污泥脱水车间设备的升级更新，还有一些污泥处置单位如垃圾电厂也在垃圾电厂内建设污泥脱水车间，脱水后的污泥进入垃圾...
View full text
板框压滤机脱水系统在水厂排泥水处理项目的应用
2022/05/08 308
前言福州市西区水厂总设计规模为60万t/d，采用絮凝池-平流沉淀池-V型滤池净水工艺，原沉淀池排泥水、滤池反冲洗水混合进入厂区排水系统，通过压力管输送至厂区外的排泥水处理场，排泥水经高密度浓缩池浓缩，排入...
View full text
板框压滤机工艺优化及自动化控制
2022/05/08 290
引言采用氨碱法生产纯碱，其中湿法蒸馏废液输送至渣场。鉴于当前环保形势，此废液处理模式已不能满足公司需求，依托集团循环经济，公司减排车间新建碱渣一期工序，主要利用澄清桶对废液稠厚后进行固液分离，其中...
View full text

Expand More

downloadingDownload

Product Classification

service

Service Support

Technical Literatureliterature

Filter Press Dewatering System for Lithium Mica Concentrate
2024/08/18 573
Lithium has a low melting point, high boiling point, the most negative potential, light weight and other characteristics, is widely used in new energy vehicles, nuclear industry, aviation, medical and other fields. Lithium is the most important basic raw material for the new energy industry, and is known as the "new energy of the 21st century". In order to accelerate the realisation of the strategic goal of "Carbon Neutral, Carbon Peak", China...
View full text
Plate and frame diaphragm chamber filter press operation process common problems and treatment
2024/07/29 607
In the coal gasification industry, the gasification filter cake is usually blended into the power coal for blending and use, but because of the high water content of the filter cake, direct blending will cause power coal plugging. In order to reduce the risk of power coal blending and plugging, it is necessary to further reduce the water content of the filter cake. Plate and frame filter press can reduce the water content of filter cake very well, so to ensure that the plate...
View full text
Optimisation of fast-opening high-pressure diaphragm filter press system in coal washing plant
2024/07/28 588
Filter press is the commonly used equipment for tailing coal treatment and dewatering in coal washing plant at this stage, which has the advantages of strong processing capacity, good dewatering effect, low noise, low energy consumption and so on. The fine coal slurry (particle size below 0.25mm) dewatering of Hupoji Coal Wash Plant uses ZKG450/2000-U type fast-opening diaphragm filter press, and the products are conveyed through the belt-type ...
View full text

View All

Contact UsAbout us